Doug is the founder of Drain Master.com Inc., Hollister, CA, which sells as well as installs Drain Master, Waste Master, 360 Siphon, HepvO and other RV waste-related products. A plug would work better as you can spray silicon spray into the hole then plug it again. Every Saturday and Sunday morning. Hardware. document.getElementById( "ak_js_1" ).setAttribute( "value", ( new Date() ).getTime() ); document.getElementById( "ak_js_2" ).setAttribute( "value", ( new Date() ).getTime() ); This site uses Akismet to reduce spam. One way to unstick your RV black tank valve is to put Dawn dish soap and water in your black tank and then drive around. Did the drill hole only difference used a small self tapping screw very gently so not to strip it out worked like a champ thanks. The first thing you need to do is make sure your black tank is empty and clean. Dave Solberg is a leading expert in the RV industry and author of the RV Handbook as well as the Managing Editor of the RV Repair Club. It is especially hard to spray lubricate into the gate valve if your RV uses a handle connected to a cable with the gate valve located somewhere further underneath the RV. What Do I Need To Use Hookups At An RV Park Or Campground? Make sure not to tighten the bolts too much, or you risk cracking the flanges. As a side note, the cable can get messed up sometimes. I don't know where I'm going but I'm on my way. They are universal, so dont worry about getting the wrong one. What to do about sticky valve handles in RV? . 2022 RVTravel.com All rights Reserved. it worked 2 weeks ago and not freezing yet. How to Install Cable Operated RV Dump Valve? Buy a tube of lubricant that contains silicon from any big box store or Amazon. I keep the cables lubed the best i can with silicone lube. You can also try tapping on your RV black tank valve with a hammer. Then you can screw a sheet metal screw into the . tried the dump the soap lube down the toilet and the shower. Occasionally, the valves are buried under the motorhome and controlled by a remote cable, which requires removing basement panels for service. Run the water until you smell the bleach, then let the tank sit for at least 24 hours after you have drained all the bleach water. Hopefully, the valve just needed a little space and it opens after just a few turns. Takes less than half a second to open and close. On our old travel trailer, I even ripped off the plastic handle to the black tank valve trying to get it to open. You can now continue with your regular RV waste tank checklist. 2014 Ford F450 King Ranch CC PSD LB DRW 4.30 Moonroof 6.7 auto Navigation Sirius/XM sony radio Air bag suspension with tank and monitor Transfer Flow 75 Gallon tank with Monitor Reese 25K hitch/goose hitch 2009 Elite Suite 36RSSB3/4 #5008 My thought is that products like the Thetford one that is mentioned, are a compound that is actually heavier than the water, and they probably sink to the bottom of the tank and collect at the seal. Thetford has a great product we have used for several years called the Drain Valve Lubricant. Only downside is that the 303 is more expensive than either of the others. This website utilizes some advertising services. Can Different RVs Use The Same Door Key? Both valves are at the back of the tanks near the end of the dropped frame. That means you can treat both the black and grey tank valves 3 times per bottle. The front gray drains out of the same outlet as the 2 black tanks. To properly dump your tanks, Paul recommends the following. U got silicone greases too. How to Market Your Business with Webinars. You may have to loosen a bracket holding the propane pipe but that is a snap too. The usual cause of what you describe is dry cables allowing corrosion to begin forming. A lot of "old-timers" use mineral oil or even cooking oil, like vegetable oil. But if youre in a tough situation with an RV holding tank valve that wont open when you need to dump your RV its a simple trick you can try. When you buy through our links, we may earn a commission. But for those who would like to know more, heres how the job has been explained to us: With the valve closed, in the area immediately adjacent to where the stainless-steel actuating rod comes out of the holding tank valve, bore a 3/16-inch hole through the plastic and into the cavity. Any suggestions for enclosed tanks and valves? How to Fix & Lubricate a Sticky Hard to Pull RV Holding Tank Dump Valve - RV Hacks, Tips & Tricks! This will not show on your comment but is for us to contact you if necessary. Apply a thin coating of grease to the seals and install them on the flanges. Oh, for goodness sakes we have a 2000 Sunnybrook travel trailer and when our grey/black tank dump valves become harder to pull, we simply spray the metal rod connected to the T handle with silicone spray (NOT WD 40). It happens to all RV owners sooner or later. To install, remove the broken waste valve and seals from your holding tank. One other item to inspect is the proper installation of the cable, if it applies to your vehicle. Stock #008828C. Your ice cube tray does a lot more than just make ice, Holy federal film permit, Batman! When RV heat is on, cabinets and counters get hot. I had forgotten what a difference this makes, valves work better than new! Now work the valve open and closed a few times. This method is kind of a long shot, especially if youre trying to unstick the black tank valve. First, keep the rod well lubricated. They have 4 tanks, 5 if you include fresh water. This site uses cookies to help personalise content, tailor your experience and to keep you logged in if you register. A very simple and inexpensive procedure is used that. Ron and Joan2005 Itasca Sunova 34A2004 Jeep Grand Cherokee Overland. any ideas be very greatful. Our tanks can be used for black and/or grey water. Charlie. WATCH VIDEO Stabilizer Jack Replacement Do-It-Yourself When it is time to replace your RV stabilizer jack, follow Matt and Bart as they demonstrate how easy it is to do this yourself. We have heard from a number of our customers that speculate this would be the answer to solve their problems once and for all. All tanks are rotationally molded of a seamless one piece, non-corrosive linear polyethylene that meets FDA acceptance and complies with Coast Guard regulations. But unless the choice of lubricants is one that will go into suspension with water, the lube will simply float on the top of the tank water and hang out there until you finally dump the tank. We're asked often about the proper method to lubricate a sticky RV dump valve. RV drain valve lubricant is to be used when the RV holding tanks are empty. By visiting our site, you agree to our privacy policy regarding cookies, tracking statistics, etc. Posted on June 27, 2022 by Thetford has a great product we have used for several years called the Drain Valve Lubricant. 5 Regrets of RV Camping in a National Park. Free shipping on orders over $100! Access to the valves is actually easy without cutting the Coroplast. Happy camper. When you empty the waste tanks in your RV, the dump valve plays a significant role. They did work but were very hard to pull out and push in. Around the Campfire: Who advocates for RVers? Could be the valves or the cables need lubricating. The cleaner the tanks discharge the better for me working underneath the trailer. I did not use much and I only worked the rod a little, being unsure if I was performing a useful process. An initial plus first or last name is the minimum, we're all friends here. By adding a Zerk fitting (grease fitting) to the dump valve assembly, they pump grease into the cavity around the steel rod. What to Do If RV Black or Grey Tank Valve Is Stuck Closed? Try and open the valve again. Our dump valves are quite stiff. Little did I know theres actually a simple fix to this issue that will also help keep the valves opening easily in the future. Realizing this was a loosing battle, I cut the sewer line that is already exposed and inserted a ball valve with two rubber couplers. RV drain valve lubricant is dumped into the grey and black tank. Forest River recalls some trailers for fridge fire risk, ST-type tire speed ratings One mans opinion. To our readers: We NEVER have or will sell reader's data. _____ John 2015 F250 6.7l 4x4 2014 Cougar X Lite 27RKS 05-28-2020, 01:47 PM . Click to visit Daves forum. Diane. I would do this as I was waiting for the tanks to dump not sure but I think they are starting to work easier. Current Projects. Some people recommend that you should never leave the gray valve open either, as it can allow odors from the parks sewer system up into your RV. Simply install the valve between your RV's sewer pipes and mount the handle on the end of the cable in a convenient, easy-to-access place. The veggie oil is a gallon jug the cheapest (~$5) stuff from Walmart or similar store. This cleans and lubricates not only the seals but the plumbing as well. Enclosed and heated dump valves; Docking station: easy winterization, Hot and cold spray port, black Tank flush, pull valves for tanks; Large tinted windows with 80/20 UV prohibitor; E-Z LUBE Dexter axles; Dexter Nev-R-Adjust brakes; Hickory Springs radius triple steps with 9" riser (no pinched fingers) Dometic "One-Touch" electric awning with . Poured a large bottle of Dawn and three pans of hot water, stomped around to make vibration so soap would agitate, and the whole tank drained in 30 mins. Make sure your tanks are empty and clean. 3 bedroom house in south east london. 1 How do you lubricate RV holding tank valves and cables? 513-401-7763 or Contact Us. We'll see how long it lasts. The idea is that the dish soap will be able to clean around the gate valve to loosen up whatever is making it impossible to open. Manually operated valves require considerable effort to operate, and there may be instances where the valve fails to function as intended. It works for a while, then I put more in. We use the rig 5-6 times a year, every 2-3 months, but the first several dumps on each trip the valves are always very stiff. In some cases the 1.5-inch gray valve gets sticky over time especially if the RVer is not using his RV full time. Sometimes the door (RV waste water valve) has issues, causing nasty leaks to happen. By adding a Zerk fitting (grease fitting) to the dump valve assembly, they pump grease into the cavity around the steel rod. This will then lube the valve seals. I've had to clean the black tank valve once before and it's a pain to have to drop the underbelly cover for this simple procedure. You use 4 fl. Mine are getting sticky, I am going to find that sprayer and foam adapter SOON. Pull the T handle all the way out, spray the metal rod, slide it in, pull it out again, spray the metal rod, slide it in, etc., etc. Molycoat is what I use too and it works really well. new 2023 venture rv sporttrek st333vik travel trailer #1538 with 31 photos for sale in blue grass, iowa 52726 . Holding the piping/flanges apart, insert the valve between the flanges being sure NOT to move the seals. It doesnt harm O rings so it should be fine for these valves. Holding the piping/flanges apart, insert the valve between the flanges being sure NOT to move the seals. What I also do after rinsing the black tank is open and close the black valve while dumping the gray tank, the soap tends to help lube the black valve seals. DO NOT USE the old standby, WD-40. One gallon of cheap vegetable oil (fry oil) at GFS is about $4.50. If you want to edit a comment click the gear icon to the right of your comment and choose edit, or delete. Plug the hole using a small screw so no waste water comes out of it when the valve is opened. If the upstream side of the valve is glued to the pipe, Id disassemble the valve then determine if its feasible to replace with most of a new valve. (877) 652-0399 Get Directions. Pretty hard to pull upwards when the compartment ceiling is in the way! DO NOT USE the old standby, WD-40. When you spray your slide-outs with lubricant each month, go ahead and spray your black tank valve as well. Rockport TX. I have easy access to mine. Perhaps you had a great day planned with your spouse, but it gets ruined because you broke your black tank valve in frustration that morning trying to dump your tanks. Living in Florida we don't put the RV into storage but I'll bet it would help if it sits for a month or so too. Some say that the best way to lubricate a sticky black or grey tank valve is to use WD-40 on the handle and inside the box that holds the gate valve when it's open. Maintenance is easy and inexpensive. Sorry for the late reply. Enclosed And Heated Underbelly; Heated Holding Tanks; Enclosed Dump Valves; Heated Dump Valves; Zero Degree Extended Season Enjoyment; Touring Edition Package. How to Replace an RV Black Tank Valve The first thing you need to do is make sure your black tank is empty and clean. Driving around with the lubricant in the tank will help it sink to the bottom faster. Safe travels, Once a year I dump some vegetable oil down each waste water tank as well as use the usual supplied straw that comes with every can of spray lube and force some lube by the handle end of the cable. Like adding water and treatment to the black tank. Click \"SHOW MORE\" for some great information about us.\rTreat us to a cup of coffee: https://ko-fi.com/theglampingguys\rStickers, Shirts \u0026 More: https://teespring.com/stores/glamping-guys-swag-3\rFollow the Glamping Guys on Instagram:\rhttps://www.instagram.com/glamping_guys/\r\r\r*********** \rABOUT US \r***********\rJason \u0026 Tod, are a married couple looking to explore this beautiful world. My RVs waste tank valves are starting to stick. Close the gate and apply a thin coating of grease to both sides. Its a relatively easy process that requires few tools. tried veg oil, also gallon dish soap,and sil grease fitting , all did not help . There may be others I don't know. I do that and it has served us well. Status: Offline. The odds of this working are greater in the grey tank but it could still work in the black tank as well. I recommend using the Thetford RV drain valve lubricant reviewed below. The contents inside the valve dry out causing the valve to stick. We are here to help, call us at. I installed screws into drilled out holes to seal them in between adding lube. It sounds like there is or was a build up in your black tank causing it to not drain. The RVers are usually referring to the black 3-inch gate valve on their black holding tank. Refill the tank, then run the water again, until the smell of bleach is gone. When you dump a tank and the handle is pulled to the open position, simply shoot the stainless rod with a good shot of lubricant spray containing silicon or Teflon. I asked that to the service manager at a SOB dealership, and he told me they use Murphy's oil. Save my name and email in browser cookies for the next time I comment so I won't have to enter that information again. What Are the Best Campgrounds in Branson, Missouri? If you prefer, you can replace the entire valve. Login; Register; Home; Shop by Categories. I followed the suggestions on the forum and added a gate valve at the end of the sewer pipe. Leaving your RVs gray valve open when fully hooked up allows you to take long showers without worrying about dumping or filling up the gray tank. Have any more questions about fixing RV black and grey tank valves that are hard to open and close? I think I saw a post a few weeks ago about something similar & he used canola oil, & dumped it in the tanks. Serving RVers for more than 20 years. Drill your hole in the center of the left or right side of the SS shaft hole, approximately 1/2 from the SS shaft. Uflex Replacement Cables; Hydraulic Oil/Power Steering Fluid; Trim Controls; Uflex Rack Steering; Your ice cube tray does a lot more than just make ice, Holy federal film permit, Batman! Around $150.00. How Much Does a Thousand Trails Membership Cost? Thank you for stopping by. Pour 1/4 bottle in each drain. To use, dump the RV like normal. The waste tank T handle is in the wet bay. Most RVs with cable pull or rod-actuated valves are positioned in the side or 3 oclock side of the exit pipe, allowing this contaminated water to lay in the bottom of the body and creating this issue over time. We're very happy to share these original songs with you for FREE, but if you're feeling inclined to help us, you can support our channel by going to any/all of these links\r Treat us to a cup of coffee: https://ko-fi.com/theglampingguys\r Stickers \u0026 More: https://teespring.com/stores/glamping-guys-swag-3\r\r\r***************************************************************\rGLAMPING GUYS MUSIC COPYRIGHT RULES INSTRUCTIONS\r***************************************************************\rYou can use our songs for personal use and to monetize your videos, but you must include the following information and music credit (below) in your video description to avoid copyright infringement.\r\r\r****************************************************************\rCOPY \u0026 PASTE TEXT BELOW INTO YOUR VIDEO DESCRIPTION\r****************************************************************\r(Insert Song Title Here) by Tod Kimbro copyright 2020 Tod Kimbro, All rights reserved.\rThe Glamping Guys Youtube Channel: https://www.youtube.com/theglampingguys\rcopyright 2020 TheGlampingGuys, All rights reserved.\r\rNow that you understand the rules, here's the SoundCloud link\rto the music.\rhttps://soundcloud.com/glampingguys\r\r\r**********************************************\rYOU MUST HAVE OUR PERMISSION TO USE, \rDOWNLOAD, OR EDIT OUR VIDEOS/MUSIC\r**********************************************\rQuestions or Request for permission to use \rour content can be sent to glampingguys@gmail.com\r\rcopyright 2020 TheGlampingGuys\rAll rights reserved.\r\rFlyover Mountain Footage in trailer provided by: Free Drone Footage\rhttp://bit.ly/Free-Drone-Footage#rvlifestyle #gaycouple #gayrvliving

Are Karen And Lee From Bridezillas Still Married, Articles H